OPTIMA NS270BRUSH

Normal diesel from the gas station, the same as you would use for your diesel car. Can not be used agricultural (red) diesel oil, neither any gasoil without a proper treatment.

Soft water, it should not contain too much minerals like calcium, iron, sodium and other minerals. The water should contain less than 40ppm of total dissolved minerals. A TDS measurer marks this number, and if the number reaches or exceeds 40 than the water has to be pre-filtered before filling up the deposits of the machine. We recommend osmosis filters and provide it with the machine if it is necessary. The water temperature has to be over 5°C. The water quality can highly affect the lifespan and efficiency of the machinery. Never use distilled water or pour chemical products to the water deposit.

Yes, both EST3 and DMF models have CE certificate by TÜV. Moreover, this is the only commercial grade steam machine on the market that has CE, Gost, cTÜVus y CSA certifications.

Yes, the Optima Steamer generates high temperature and relatively low pressure steam (ca. 8 bars) but powerful enough to remove all kind of dirt of any surfaces. Instead of cleaning by high pressure water the Optima Steamer uses the heat to lifts up dirt and mud from the car surface quickly and effectively. In addition the Optima Steamer has a moisture control valve that allows the operator to increase or decrease the moisture content. Wet steam is used to clean heavily soiled part of the vehicle meanwhile dry vapor steam sanitizes and refreshes interiors.

The main difference between the two models is the boiler heating source. According to that there are a fuel-run type XD and the full electric, 3-phase XE models. The XE series need an industrial 380V power source and is recommended for stationary use where there is no proper ventilation is available (e.g. underground parking). The Optima XD is the most popular steam generator of our range as it is completely mobile and can be used for both stationary and mobile service.

All Optima Steamer DMF machines are mobile units although it needs to be plugged to an electricity point but consumes as little as 350W. To obtain such a small amount of electricity the machine could be run from a battery with an inverter, but we recommend a portable electric generator that also supplies electricity to a vacuum cleaner. A 2000W electric generator would serve perfectly the two machines. We can also recommend one if necessary.

Yes, you can utilize our professional steam cleaning machine for various interior cleaning tasks such as upholstery and rug cleaning, stain removal, deodorizing, air conduct disinfection, leather and plastic cleaning etc. Using high temperature saturated vapour steam (reaches 110°C) is the only natural way to sanitize and disinfect surfaces eliminating bacteria, moulds, dust mites and microorganisms causes bed small and discomfort.

Although the Optima Steamer is very efficient chemical-free cleaning equipment, there is a possibility to incorporate detergent into the steam wash. All products apply before or after the steam cleaning process by a spray bottle or atomizer, but never put chemical products into the water tank. As an optional accessory there is a spray bottle to connect to the steam gun’s tip that will spray a mixture of steam with detergent. We recommend using the spray bottle before passing only steam and the microfiber cloth. Biodegradable products are highly recommended, please consult us about cleaning products availability.

For car cleaning purposes in a service centre or doing it mobile the most important accessory is the high quality microfiber cloth what we also provide. It is obligatory to dry the vehicle properly. Although your accessory purchase decision will be based on the application and type of services you offer. Please contact us for the complete list of accessories available for the Optima Steamer

The Optima Steamer is designed for two users (comes with two steam hoses and guns). Considering this scenario two experienced steam car cleaner can wash at the same time, finishing a car exterior in 10-15 minutes depending on the car size and dirt level. If only one person is cleaning the vehicle it can take the double time, up to 20-30 minutes depending also on the person’s skill level.

The water deposit capacity of the Optima Steamer DMF is 20 litres. If we consume 4-6 litres of water per car wash we should refill the water tank after every four washes. However the low level sensor in the water tank will go off before using up all 20 litres. When two operators are working with the machine continuously the water tank should be refilled once in an hour. The EST3 has a 40 litres water tank, which allows operating it two times more with one refill.

The fuel tank capacity of the Optima Steamer XD is 20 litres. It takes about 0,5-0,9 litres of gasoil per car wash. With one tank full of diesel we should be able to clean up to 30 cars, although the minimum level sensor of the diesel tank will go off when 15 litres of the gasoil has been consumed. This is another safety feature of the machinery.

The Optima Steamer is designed for 24 hours operation on 365 days a year. There is no waiting time between washes what so ever, the machine keeps the same steam pressure and temperature. In fact, the fuel and electricity efficiency is the highest when used continuously. Indeed, there are couple of minutes of preheating time in the beginning of the day.